BMW X3 Service & Repair Manual: Suspension
BMW X3 Service & Repair Manual / Suspension
- Front axle repair instructions
- Danger of poisoning if oil is ingested/absorbed through the skin
- Front axle + steering: wheel alignment check must be carried out after the following work
- Information on replacing shock absorbers
- Lifting the vehicle using a vehicle hoist
- Mobile table lift
- Notes on repairing threads (A)
- Raising vehicle with trolley jack
- Risk of injury if oil comes into contact with eyes and skin
- Safety information for working on vehicles with automatic engine start-stop function (msa)
- Safety instructions for handling oil
- Front axle suspension
- Front sub-frame
- Struts with rubber mounts
- Removing and installing left or right wishbone
- Removing and installing/replacing guide joint in swivel bearing
- Removing and installing/replacing left or right trailing link
- Replacing rubber mount in left or right control arm
- Replacing rubber mount in left or right trailing link
- Wheel bearings and stub axle
- Removing and installing/replacing left or right swivel bearing
- Replacing bearing for front wheel
- Replacing wheel bearing for front wheel
- Spring strut
- Information on replacing shock absorbers
- Removing and installing complete left or right spring strut shock absorber
- Removing and installing/replacing trailing link on left or right spring strut dome
- Replacing front left or right spring strut (edc)
- Replacing front left or right spring strut shock absorber
- Spring with suspension
- Stabilizer bar
- Front axle gearbox
- Check/change front axle differential oil
- Removing and installing/replacing front axle differential
- Removing and installing/replacing left or right output shaft
- Front axle
- Adapter
- Basic body
- Bolt
- Bush
- Device
- Extractor
- Fixture
- Fork
- Gauge
- Holder
- Holding sleeve
- Insert
- Mandrel
- Measurement aid
- Pin
- Pin wrench
- Ring
- Screw
- Shaped part
- Socket waf 46
- Spindle
- Spring tensioner
- Synchronising key
- Tool
- Tool set
- Washer
- General information on high temperature multi-purpose grease
- Integrated suspension systems repair instructions
- Carry out ride height adjustment
- Danger of poisoning if oil is ingested/absorbed through the skin
- Risk of injury if oil comes into contact with eyes and skin
- Safety information for working on vehicles with automatic engine start-stop function (msa)
- Safety instructions for handling oil
- Front control and suspension elements
- Rear control and suspension elements
- Carry out ride height adjustment
- Removing and installing rear left or right spring strut shock absorber (edc)
- Replacing rear left or right spring strut shock absorber
- Electrical components
- Removing and installing/replacing control unit for vertical dynamic control
- Replacing front ride-height sensor
- Replacing left or right wheel speed accelerator sensor
- Replacing rear ride-height sensor
- Electronic damping force adjustment
- Removing and installing/replacing control unit for vertical dynamic control
- Replacing left or right wheel speed accelerator sensor
- Integrated suspension systems
- Approved hydraulic fluids
- Rear axle repair instructions
- Danger of poisoning if oil is ingested/absorbed through the skin
- Information on replacing shock absorbers
- Lifting the vehicle using a vehicle hoist
- Measuring vehicle ride height
- Raising vehicle with trolley jack
- Risk of injury if oil comes into contact with eyes and skin
- Safety instructions for handling oil
- Final drive
- Removing and installing/replacing rear differential
- Replacing shaft seal(s) for output shaft(s) in rear axle final drive
- Final drive with cover
- Checking/topping up oil level in rear differential
- Replacing radial shaft seal for input flange of rear axle differential
- Replacing rear cover gasket on rear axle final drive
- Replacing rear cover gasket on rear differential (188lw)
- Replacing rear cover gasket on rear differential (215lw)
- Final drive mounting
- Replace the rubber mounts for the front of the rear axle final drive suspension
- Replacing the rubber mounts for the rear axle final drive suspension at rear
- Output shafts
- Pressing output shaft out of drive flange and drawing in
- Removing and installing/replacing both output shafts
- Rear sub-frame
- Lowering/raising rear axle support
- Removing and installing complete rear axle support
- Replacing rear axle support
- Control arms and struts
- Removing and installing/replacing a steering stub/wheel carrier
- Removing and installing/replacing left or right camber arm
- Removing and installing/replacing left or right toe arm
- Removing and installing/replacing left or right underbody panelling
- Replacing a ball joint in lower steering stub/wheel carrier
- Replacing a control arm
- Replacing an upper wishbone
- Replacing left or right trailing arm
- Replacing rubber mount for trailing arm in wheel carrier
- Replacing rubber mount for wishbone in wheel carrier
- Axle mounting
- Replacing left or right rear axle support compression strut
- Replacing two rubber mounts for rear axle carrier
- Wheel bearings
- Detaching wheel bearing inner ring from drive flange (drive flange removed)
- Replacing drive flange on left/right rear axle shaft
- Replacing left or right wheel bearing on rear axle shaft
- Shock absorber
- Information on replacing shock absorbers
- Removing and installing rear left or right spring strut shock absorber
- Springs with suspension
- Stabilizer bar
- Removing and installing/replacing rear anti-roll bar
- Replacing both rubber mounts for anti-roll bar mounting
- Rear axle
- Adapter
- Basic body
- Bush
- Device
- Extension
- Fixture
- Frame
- Holder
- Holding sleeve
- Insert
- Mandrel
- Nut
- Plate
- Pliers
- Ring
- Rod
- Screw
- Shaped element
- Shaped part
- Shell
- Socket wrench
- Spindle
- Spring cups
- Spring tensioner
- Synchronising key
- Tool
- Washer
- Wrench
- General information on final drive oil
- Approved final drive oils for front and rear axle final drives with and without limited slip or viscous coupling
- Final drive oil for bmw m1 motorsport coupe
- Operating fluids as of 11/2015
- Hypoid oils for differential x5/x6 rear axle transverse moment distribution (qmvh transmission)
- Hypoid oils for final drive without disc-type limited-slip differential
- Hypoid oils for final drive unit with disc-type limited slip differential (m models and with sa209 self-locking differential)
- Final-drive gear oils for bmw m1 motorsport coup
- Electronic chassis alignment
- Additional work for camber correction
- Adjusting rear axle
- Adjusting toe-in on front axle
- Danger of poisoning if oil is ingested/absorbed through the skin
- General information and definitions
- Kds chassis/wheel alignment check with vehicle load up to design position
- Kds wheel alignment check with ride height measurement without vehicle load
- Moving vehicle into design position
- Notes on replacement of steering gear/steering column/steering shaft following accident damage
- Rear axle: wheel alignment check must be carried out after the following work
- Risk of injury if oil comes into contact with eyes and skin
- Safety information for working on vehicles with automatic engine start-stop function (msa)
- Safety instructions for handling oil
- Mechanical steering gear
- Notes on checking steering backlash on vehicles with rack-and- pinion steering
- Notes on replacement of steering gear/steering column/steering shaft following accident damage
- Replacing gaiter for steering box on left or right
- Steering gear with servo unit
- Notes on replacement of steering gear/steering column/steering shaft following accident damage
- Replace electrical steering box (eps) (N52/N55/N57)
- Replace electrical steering gear (eps) (N20/N47)
- Replace electrical steering gear (eps) (N20/N47)
- Steering arms, tie rods, steer. damper
- Instructions for removing and installing ear clips
- Removing and installing/replacing left or right track rod end
- Replacing (removing and installing) left or right track rod
- Steering column
- Removing and installing/replacing lower section of steering column shroud
- Removing and installing/replacing steering column
- Removing and installing/replacing universal joint with corrugated tubing
- Removing and installing/replacing upper section of steering column shroud
- Replacing steering column adjustment lever
- Replacing steering shaft sleeve
- Steering wheel
- Removing and installing/replacing sport steering wheel
- Removing and installing/replacing steering wheel
- Steering wheel for airbag
- Procedure after airbag deployment as result of an accident
- Removing and installing/replacing airbag unit
- Removing and installing/replacing airbag unit (sports steering wheel)
- Safety regulations for handling components with gas generators
- Pump and oil supply
- Steering and wheel alignment
- Adapter
- Basic body
- Bush
- Clamp
- Device
- Extractor
- Gauge
- Holder
- Mandrel
- Open-end wrench
- Outpusher
- Pin wrench
- Screw
- Spindle
- Synchronising key
- Tool
- Wheels
- Checking one road wheel on balancing machine for lateral and radial runout (wheel removed)
- Checking wheel rim for lateral and radial runout
- Notes for repairing aluminum rims
- Remove or install front or rear wheel
- Stationary wheel balancing
- Disc wheels (rims)
- Checking wheel rim for lateral and radial runout
- General information on light alloy disc wheels
- Initializing run flat indicator (rpa)
- Removing and installing rdc (tire pressure control) control unit (low cost)
- Removing and installing/replacing rdc wheel electronics (2nd generation/3rd generation)
- Tires
- Wheels with tires
- Tire mounting paste
Sprayer
Sprayer AM
NOTE: For cleaning the IHKA and IHKR1 A/C system evaporator
SI number
01 06 91 (398)
Consisting of:
1. Spray lance
NOTE:
(Guid ...
Other materials:
BMW X3 Service & Repair Manual > Side frame and door pillars: Replacing A-pillar with reinforcement on the left (with side member
attachment)
Procedure OBSERVE repair stage 3!
Read contents of BODY, GENERAL.
Spot-weld bonding is used on this vehicle. Observe specific PROCEDURE.
Use only approved SPOT-WELDING APPARATUS for repairs.
Place vehicle on straightening bench.
Following new body parts are required:
(1) A-pillar wi ...
BMW X3 Owners Manual
BMW X3 Service & Repair Manual
© 2017-2024 Copyright www.bmwx3tech.com - 0.0252