BMW X3 Service & Repair Manual: Checking/topping up oil level in automatic transmission (GA8HP45Z, GA8HP50Z, GA8HP90Z)

BMW X3 Service & Repair Manual / Transmission / Transmission in general / Checking/topping up oil level in automatic transmission (GA8HP45Z, GA8HP50Z, GA8HP90Z)

IMPORTANT:

  • Do not let skin come in contact with transmission oil and do not inhale fuel vapors.
  • Wear protective gloves.
  • Ensure adequate ventilation

IMPORTANT: Use only the approved TRANSMISSION OIL .

To set the correct level, it is mandatory that the service function "Transmission control unit: oil adjustment" is performed using the diagnosis system.

Failure to comply with this requirement will result in serious damage to the automatic transmission. Conditions for the oil adjustment:

  • Initial condition: Transmission oil temperature 30 º C to 40 ºC
  • Final condition: Transmission oil temperature 40 º C to 50 ºC

IMPORTANT: Transmission GA8HP70Z with N57 engine from 03/2011!!

Precondition for oil adjustment

  • Transmission oil temperature 30ºC to maximum 40ºC.

(The transmission oil temperature must be maintained. This will increase the oil quantity in the transmission.)

Performing oil-level adjustment:

An oil-level adjustment is necessary for certain fault code entries in the automatic transmission and after repair (e.g. mechatronic replacement, converter replacement, transmission replacement).

  • Connect diagnosis and information system.
  • Service function (transmission control unit: Oil adjustment) call up
  • Carry out oil level check in accordance with instructions

Adding transmission oil:

Stand vehicle on a level surface and secure against rolling off.

Undo oil filler plug (1).

Add automatic transmission fluid according to instructions in the BMW diagnosis system.

Transmission

Installation note:

Replace sealing ring/oil filler plug Tighten down oil filler plug using

  1. Hexagon socket wrench AF 8
  2. Torque wrench
  3. Socket AF 8

Transmission

    Danger of poisoning if oil is ingested/absorbed through the skin
    Danger of poisoning! Ingesting oil or absorbing through the skin may cause poisoning! Possible symptoms are: Headaches Dizziness Stomach ach ...

    Installing exchange transmission (GA8HP45Z) (N52, N55, N47)
    IMPORTANT: Do not let skin come in contact with transmission oil and do not inhale transmission oil vapors. Wear protective gloves. ...

    Other materials:

    BMW X3 Service & Repair Manual > Luggage compartment floor: Replace luggage compartment floor and both side members (tail panel trim removed)
    Read contents of BODY, GENERAL. STRIP DOWN VEHICLE Place vehicle on straightening bench. Observe procedure of REPAIR STAGE 3. Following new body parts are required (refer to OVERVIEW OF CONSUMABLES): (1) Wheel arch extension, rear left and right (2) Luggage compartment floor, left an ...

    BMW X3 Owners Manual

    BMW X3 Service & Repair Manual

    © 2017-2020 Copyright www.bmwx3tech.com - 0.0073